Poured liners
A cement based mix is poured around a form inside the chimney to create a smooth new flue which suits some older or irregular chimneys.
Chimney Parts
Chimney Liner Installation Albrightsville, PA
A sweep in Albrightsville can reline an unlined or damaged flue so smoke and gases vent safely from a fireplace, stove, insert, furnace or water heater. Call (272) 233-1004 to reach a local chimney sweep.
A chimney liner is the channel inside the chimney that carries smoke and combustion gases up and out. It keeps heat from reaching wood framing next to the chimney, protects the brick and mortar from corrosive gases and gives the appliance a flue of the right size to draft well. In older houses, it is common to find an unlined chimney or a clay tile liner that has failed.
Relining usually comes up for one of a handful of reasons. Clay tiles crack after chimney fires, shift as the house settles and lose mortar at the joints, while some chimneys never had tiles to begin with. A new fireplace insert, wood stove or furnace also usually calls for a liner sized to that appliance, since an oversized flue drafts poorly and builds up creosote or condensation.
Before relining, the chimney should get a thorough inspection, usually a Level 2 inspection with a camera run up the flue. The inspection tells you whether relining is truly needed and what kind of liner suits the chimney. Ask to see the camera video so you understand what was found.
Chimney Liner Installation is often paired with chimney liner repair and chimney inspection, depending on the cause.
Need chimney liner installation in Albrightsville? Call (272) 233-1004 and describe the problem to a chimney sweep who works in Albrightsville.
Call nowThe process
The chimney relining process
Here is how a sweep usually handles a liner installation.
Scan the chimney
A camera is run through the flue to check the existing tiles, offsets and obstructions. This confirms what kind of liner the chimney needs.
Size the liner
The right diameter depends on the stove, insert, furnace or fireplace being vented. The route and any offsets are noted.
Prepare the chimney
Before the liner goes in, the chimney is swept and cleared. Some chimneys need old tiles broken out to fit an insulated liner.
Install the liner
The liner goes in from the top, with insulation added where the system requires it. Many liner systems are tested with insulation for clearance to combustibles.
Connect the appliance
The bottom connects to the stove, insert or appliance, and the top is sealed with a top plate and cap. A sealed system is the whole point of relining.
Confirm venting
A draft test confirms the new liner is working. Make sure working CO alarms are in place near sleeping areas.
What is included
What chimney liner installation covers
Furnace flue liners
Liners sized for gas and oil appliances so the appliance drafts and the masonry stays dry.
Flex liners
Flexible stainless steel liners bend around offsets in the chimney and are common for inserts, stoves and gas appliances.
Rigid liners
Rigid stainless sections join together in straight chimneys which suits wood burning appliances well.
Liner insulation
An insulation wrap or poured insulation surrounds the liner which improves draft and limits creosote.
Related service
Stainless Steel Chimney Liner Albrightsville, PA
Most relining jobs use stainless steel, which handles high heat and corrosive flue gases well. It comes in flexible coils for chimneys with bends and rigid sections for straight flues. Liners are sold as tested systems, with grades suited to wood, gas or oil.
Insulation around the liner helps flue gases rise and keeps the outside of the chimney cooler. The top of the liner is sealed with a plate and covered with a cap. Many Albrightsville chimneys get a stainless liner when an old fireplace is converted to an insert.
Related service
Chimney Relining Albrightsville, PA
A chimney is relined when the existing flue cannot safely vent the appliance. The most common triggers are chimney fires, settling cracks, missing mortar and appliance changes. In most cases the work is done from the top without tearing into the house.
Before relining, it helps to know which appliances share the chimney. An orphaned water heater, left behind when a new furnace vents elsewhere, is a common reason to reline. A properly sized liner fixes that.
Local help
Chimney Liner Installation Near Me
Many chimneys in Albrightsville were built long before modern liners were standard. Homes in Albrightsville and neighboring towns like Indian Mountain Lake, Sun Valley, Sierra View and Emerald Lakes often switch to inserts, stoves or high efficiency furnaces, which changes what the flue needs, which is why relining is one of the most common chimney upgrades in the area.
Need chimney liner installation around Albrightsville? Call (272) 233-1004 for an Albrightsville chimney sweep who serves the towns around it too.
Chimneys in this climate
Winters here are long and cold, and the heating season usually runs from October well into April. The hardest thing on brick here is not the cold itself but the constant swing above and below freezing: rain and melting snow soak into the crown and joints, then freeze and push them apart, which is how cracks, loose bricks and leaks start. Nor'easters drive rain sideways into flashing and mortar that looked fine in summer. Most homeowners in Albrightsville, PA schedule a sweep in early fall, and a repair check after a hard winter.
Why call
Why act early
Less damage
A chimney problem fixed early rarely spreads to the masonry, the liner or the house.
Local knowledge
Local sweeps see the same chimney types and weather wear across Albrightsville and nearby towns.
Know what happens next
Ask the sweep about the cause, the options and the estimate before work starts.
Chimney Liner Installation questions
What is the difference between a clay liner and a stainless liner?
The original liner in most masonry chimneys is clay tile, which is durable until a chimney fire or settling cracks it. Stainless steel liners are installed later, from the top, and are used to reline chimneys whose tiles are damaged or missing. Minor tile damage can sometimes be repaired instead.
How long does a stainless steel liner last?
A quality stainless liner, installed and maintained properly, can last for decades. Chimney fires, heavy creosote and corrosive condensation are what shorten their life. Annual inspection helps catch problems early.
What is an orphaned water heater?
After a furnace upgrade, the water heater may be the only thing left using a flue that was sized for two appliances. That flue is now too big for the water heater, so gases cool, draft weakens and condensation can damage the masonry. The fix is a properly sized liner, plus CO alarms in the home.
Can an insert vent into an existing chimney without a liner?
NFPA 211 expects a positive connection from the insert to the flue, and a full length liner is the common way to do it. Without a liner, smoke and creosote collect in the oversized flue. Check the insert installation instructions for details.
Why would a chimney need a liner?
The liner is what contains the heat and gases from the fire or appliance. Fire codes and safety standards expect chimneys serving fireplaces and appliances to be lined. A sweep can check the flue and tell you where you stand.
More questions? Call (272) 233-1004
Often needed together
Chimney Liner Repair
Fixing gaps, cracks and missing mortar inside the flue liner with resurfacing, joint repair or partial replacement.
Learn moreChimney Inspection
A top to bottom check of the chimney, inside and outside so you know whether it is safe to light a fire.
Learn moreFireplace Insert Installation
Fitting a fireplace insert so an open fireplace becomes a real heat source, sized to the firebox and vented through a full-length liner.
Learn moreWood Stove Installation
Wood stove installation into an existing chimney or a new insulated chimney, with stovepipe, liner or chimney sized to the stove.
Learn more
Looking for something else?
See all chimney servicesTalk to an Albrightsville chimney sweep about chimney liner installation
Call (272) 233-1004 for a local chimney sweep in Albrightsville and nearby towns.
(272) 233-1004
Free to call. No forms to fill out.